1997 Chevy GMC Truck Brake Controller Installation

R and P Carriages


Home Trailers Parts Rentals Help Section Contact Us

1997 Chevy GMC Truck Brake Controller Installation
(Other Years May Be the Same or Similar)

Please visit my general install page for overall instructions

I sell brake controllers, so please, if you need one click here! We keep Prodigy P2 Brake Controllers in Stock Regularly!


"Standard" Wire Colors from Chevy Trucks


When using a wiring harness supplied by your vehicle’s Manufacturer (OE Harness), DO NOT MATCH COLORS. Please follow wiring chart below

Chevy Wiring
Brake Controller Wiring
Function
Red Black +12 Volts
Light Blue Red Stop Light
Black White Ground
Dark Blue Blue Trailer Brakes
Brown NA  


Remember, the above colors are just a GUIDE. your colors may be different, read the instructions!

1997  Chevy Truck Brake Controller Installation

We found the brake light switch tap on the panel, and used a standard 1/4" spade connector to connect it (red wire is from brake controller)

Get a test light and test all the un-used pins on this panel, looking for the one that lights up when you press the brake pedal. If you can not find any that light, you will forced to find the brake light switch wire under the dash. The brake light switch is very hard to reach, but with a probe tester, look for a wire under the dash that lights with the brake lights. I " THINK " (from memory), you are looking for a small gauge white wire. Tap into the wire for the brake light feed (red wire on most controllers)

1997  Chevy Truck Brake Controller Installation

We used this stud (powered by the 30 amp green fuse) to power the brake controller, and supply power to the 12 Volt power terminal on the trailer plug. This truck did not have wire ran to the back, so we used our 2 conductor brake wire and ran it ourself. Drilled a small 3/8" hole in a rubber plug in the fire wall to run the wire to the brake controller under the dash.

1997  Chevy Truck Brake Controller Installation


Still Have More Questions? Email Paul!

 

 


Home | Trailers | Parts | Rentals | Help Section | Contact Us
Questions? Email the Webmaster!
Copyright© R and P Carriages 2015